This foundation repair information pertains exclusively to dealing with foundation repair situations found in Dallas Ft Worth (DFW) area clay soil. Different soils and foundation types demand different repair methods. There is no single magic bullet for repairs across all of America.

We will look at:

• The best foundation repair system, comparison of steel and pressed concrete piers or piles
• Mud jacking pros and cons
• Why void filling under a slab is not always good
• How straightly installed are steel piers and concrete pilings
• Why concrete piers will rust

Myth 1) The best foundation repair system is a "self testing system" driven to refusal. Steel systems are typically driven to a rock strata, while pressed piling systems are more often, "driven to refusal". Refusal means that you cannot push the pier system downward any deeper.

In the case of pressed or pre-cast concrete pilings or piers, refusal typically means the concrete piling system has been pushed to compressed clay. Pressed concrete pilings seldom are driven deeper than 15 feet, and in many areas achieve "refusal" at depths of 6-10 feet. Concrete piling depth is extremely dependent upon soil moisture content.

Here are actual comparisons of piling depths obtained during two foundation repairs. In each case, steel piers were proven to provide better depth than pressed concrete pilings, with much less stress on the house.

	Steel Pier	Pressed Concrete Piling
Site 1	30 feet to refusal	15 feet to refusal
Site 2	18 feet to refusal	8 feet to refusal

Myth 2) Mud jacking is a good low cost way to lift a foundation Seldom does mud jacking provide house leveling results that are satisfactory for the long run. Sometimes, mud jacking is even destructive to the house. Most companies only resort to mud jacking as a last resort for foundation repair for a very weak foundation and may require a damage waiver prior to beginning repair.

Myth 3 ) The void under a slab foundation should always be filled after the house has been lifted. Foundation repair companies will seldom fill the void, to allow for normal soil expansion during wet periods. When a void is filled in an area where the clay is not maximally expanded, adding water to the expansive clay may force the void fill material up through the floor. Expansive wet clay soil is stronger than the typical 4-5 inch thick slab foundation.

Myth 4) Steel piers and pressed pilings can be installed crooked, leaving the house unstable. During the pile driving process, the soil forms a rigid wall, constraining each section of pipe or concrete to follow the next straight down. Neither steel or concrete is driven in a crooked manner by a competent installation team. Just ask your engineer.

Myth 5) Concrete piers are best because they will not rust. Contractors pushing concrete foundation leveling systems want you to think that concrete is superior because steel piers will rust.

Here is a revelation in concrete piers systems. At the top of each concrete pier system there is a nent stack 1 to 4 inches thick of ¼ inch thick steel shims. The steel shims are a fundamental part of each concrete pier house leveling andn foundation repair.

Truth is that if rusting steel were a problem, it would be most evident in the poured concrete or pressed concrete piling foundation repair systems. When foundation repair systems are left undisturbed underground, a thin protective layer of rust forms on the steel shims, as well as on steel pier systems.

Steel pier systems are predominantly made up of high carbon steel which is less susceptible to the effects of oxygen and water on steel.

Recent changes in many Dallas, Fort Worth, Arlington, Grand Prairie, Plano, Garland and other local DFW municipalities' building codes mandate steel shims rather than wood shims for pier and beam houses.

Repair Methods

• Steel piers
• Helical piers
• Concrete piers
• Soil injection
• Mudjacking
• Drainage
• Tunneling
• Root barrier

FIND OUT MORE

Foundation Problem Signs

• Brick cracks
• Sloping floor
• Sticking window
• Cracks in walls
• Cracks in floor
• Cracks in tile
• Sunken floor
• Bouncy floor (Pier & Beam)

FIND OUT MORE

Granite's Lifetime Warranty

All of Granite's foundation repairs are guaranteed by a fully transferable warranty. Our goal is to fix it right the first time and we stand behind our work. Learn more about our lifetime transferable warranty...

FIND OUT MORE

Granite Foundation Blog

Subscribe to RSS headline updates from:

What Are My Repair Options?

Frequently Asked Questions

Why Choose Granite?

Granite's Lifetime Warranty

Repair Methods

Testimonials

Signs of Problems

Causes of Problems

Service Area

Foundation Articles

Foundation Design

Why Repair Now?

Foundation Repair Forum

Sitemap